Popular RV and Boat Maintenance Services in Cookeville, TN
Your RV and boat are unique and different than the car you drive in a lot of ways. It's more than just transportation from one place to the next. It's your home on the road. It's your safe haven. It's your base for exploring and adventuring in ways that non-RVer's have never experienced. So why trust service to anything less than the best in the industry? No one is more equipped, more trained and more skilled than the technicians at Cookeville RV and Marine to handle everything from routine maintenance to major repairs on virtually every make and model of RV or boat. You can rest assured that every job, no matter how big or how small, will be done expertly and efficiently.
For operation safety & fuel efficiency
- Clean main burner orifice
- Clean/Inspect/Adjust electrode assembly
- Clean blower wheel
- Test module board/inspect & clean board contacts
- Clean & inspect combustion chamber
- Inspect fan motor
- Clean & inspect vent tubes and outer casing
- Reassemble furnace using new gaskets
- Water pump operation
- Check all faucets
- Check holding tanks
- Check fresh water fill
- Complete water line pressure test
- Check all gate valves
Manufacturers recommend this service every 75 operating hours or 12 months
- Change oil and filter
- Service includes required oil and filter. If needed, generator removal & any additional parts will be an extra charge
- Verify unit is air tight in compartment
- Refrigerator is properly vented (roof and sidewall)
- Clean and adjust burner and orifice
- Inspect and test all door seals
- Check LP Pressure and proper voltage
- Clean roof vent and check baffle
- Clean & Check Battery & Connections
- Visual Inspection of Exhaust System
- Clean Spark Arrester
- Verify CO Detector & Operation
- Check Air Filter - Replace as Necessary
- Change Oil & Filter
- Check Fuel Filter/Replace as necessary
- Perform Load Test
Manufacturers recommend this service annually
- Clean rubber roof with specially designed cleaning agents
- Apply UV-Blocking treatment to protect rubber membrane
We Offer Roof Inspections:
- Roof Leak Checks
- Rubber Roof Replacement
- Roof Repairs
- Roof Seam Seals
- Check for proper LP pressure & adjust as needed
- Check for accumulation of dirt, grease, dust or spider webs
- Light each range burner one at a time, check for variable flame
- while rotating the valve
- Test oven temperature
- Drain fresh water tank and water heater
- Blow out water lines with compressed air
- Fill P-Traps with anti-freeze
- Pump antifreeze through fresh water lines
- with water heater bypass already installed
- Winterize ice maker and/or water filter
For operation safety and fuel efficiency
- Check condition of Anode Rod
- Check relief valve
- Adjust burners and electrodes
- Check thermocouple
- Check module boards
- Check complete operation
- Check burner assembly, remove nests, bugs, webs, etc.
- Check air temperature drop across the evaporator coil
- Check compressor voltage
- Check compressor amperage
- Remove and clean A/C Filter
- Examine Shroud for cracks and damage
- Clean and unclog A/C roof drains
Bearing Packs Include
- Inspect brake shoes, bearings and magnets
- Clean & repack wheel bearings
- Adjust brake linings as needed
- Verify the operation of the electric brake magnets & break-away switch
- Grease seals are extra, prices vary by axle size
- If bearings require replacement additional charges apply
Electrical System
- 12 volt
- All lights
- Monitor panel
- 110-Volt system priority
- Converter operation and output
- Shore cord and circuit breakers
- Generator operation and output
- Inspect regulators and LP tanks
- Complete a drop down pressure test
- Complete a line pressure test
- Check all LP detectors
Includes comprehensive inspection points in these areas
- Check all electrical outlets
- Check inverters and converters
- Check generator systems
- Check plumbing for leaks and proper operation
- Check LP systems
- Check all appliances
Check the following for proper operation
- Antennas
- Furnace
- DVD Players
- Roof - A/C
- Water Heater
- Refrigerator
- Range/Oven
- Awnings
- TV's
- Washer/Dryer